Heat Leak? wtf?!?
#1
Senior Member
Thread Starter
Join Date: Sep 2001
Location: Marietta, Georgia
Posts: 565
Likes: 0
Received 0 Likes
on
0 Posts
Heat Leak? wtf?!?
Ok -- here is the latest installment in the ongoing storybook of ailments and mazda diseases...
I leave the house around 10:00pm I drive for about 15-20 minutes. Park the car, meet with some friends... we decide to go driving... I get back into my car 10 minutes later (after parking) to find a film on the inside of my windshield. It is not moisture or 'fogging up' it is a thick film that literally has to be pressured off with a cloth! window cleaner doesnt even cut this stuff... lately with it getting cooler outside, the problem has been getting worse and worse, sometimes i come back to a completely funked windshield, other times it is just in small places... My guess is Radiator Steam... but what the hell, it only noticed this after I changed my heater-core to block coolant hose... everything is tight and there are NO coolant leaks.... what the heck is going on?
This problem is VERY irritating as it takes a good 5 minutes to get the Windshield to where i can see out...Any suggestions would be greatly appreciated...
Oh yes, this in the 89 NA... thank you...
I leave the house around 10:00pm I drive for about 15-20 minutes. Park the car, meet with some friends... we decide to go driving... I get back into my car 10 minutes later (after parking) to find a film on the inside of my windshield. It is not moisture or 'fogging up' it is a thick film that literally has to be pressured off with a cloth! window cleaner doesnt even cut this stuff... lately with it getting cooler outside, the problem has been getting worse and worse, sometimes i come back to a completely funked windshield, other times it is just in small places... My guess is Radiator Steam... but what the hell, it only noticed this after I changed my heater-core to block coolant hose... everything is tight and there are NO coolant leaks.... what the heck is going on?
This problem is VERY irritating as it takes a good 5 minutes to get the Windshield to where i can see out...Any suggestions would be greatly appreciated...
Oh yes, this in the 89 NA... thank you...
#3
Senior Member
Join Date: Oct 2001
Location: Grand Rapids, MI
Posts: 596
Likes: 0
Received 0 Likes
on
0 Posts
If manual tranny check the rubber boot beneath the outside shift cover. Had same problem had to use ammonia at times to get the film off inside winshield and rear hatch window. Just as a coincidence found the inner boot rotted away, almost a jelly. Apparently the rubber was eaten away by a small seal leak in the shifter. Installed a new seal and problem went away. Did not make the connection at the time and still not certain how the two were connected (boot and windshield film). But the filming up went away.
#4
Senior Member
Thread Starter
Join Date: Sep 2001
Location: Marietta, Georgia
Posts: 565
Likes: 0
Received 0 Likes
on
0 Posts
I have a manual trans, but i can see where the the film starts building up, its coming from the Defrost Vents... so maybe i am leaking coolant into the car.,.. SCOTT, how do I tell??
#6
Senior Member
Thread Starter
Join Date: Sep 2001
Location: Marietta, Georgia
Posts: 565
Likes: 0
Received 0 Likes
on
0 Posts
will do -- now there isnt any smell of radiator fluid anywhere in the car. I havent checked for the wetness, but i know the HC isnt something that I want to replace... i dont like taking apart dashes...
thanks..
thanks..
Trending Topics
Thread
Thread Starter
Forum
Replies
Last Post
t-von
3rd Generation Specific (1993-2002)
9
09-10-15 01:56 PM
ZaqAtaq
New Member RX-7 Technical
2
09-05-15 08:57 PM