Need help!!! Searched for hours!
Well i've been trying my hardest to get my 1991 S5 to run. I've searched endlessly on this forum and i can't find what im looking for. Well let me tell you that the car has been sitting for 4 years and some change and i know that things would seize up. The car ran before pefectly fine because i was going to buy this car that long ago but someone broke into it, stole important interior stuff ,and was left sitting for that long. So the owner gave up on selling it and just gave me the car for free!( the car is in pretty damn good condition in its current state! which is what i'm told by other seven guys who've seen it). I cleaned most of the fuel system (including the gas tank which took long as hell to do) I have gotten the car started with starter fluid, ran till the fuild ran out but that was before i had my injectors professionally clean. Also i replaced the fuel pump to a walbro 255 unit. I don't know if i need a fuel pressure regulator to see if i have fuel pressure. i've also tried putting oil in the leading spark plug whole? (don't know if this helps). I would love your help so any advice i will be most greatful! this was going to be my first car in high school but that unfortunate event happened. PLEASE WOULD LOVE TO GET HER RUNNING TODAY!!!!!
|
So what are you asking?
Yes you need a FPR, are you getting fuel into the housings? |
Sorry. I was asking what else do i need to do to get her running again. one of my buddies suggested that i slowly push start it. would this be a bad idea
|
does it turn over fine? if it been sitting that long, squirt a little of auto tranny fluid into each rotor through the spark plug hole. this adds to compression for an easier start. then get some starting fluid and spray it into the throttle body as you crank. if this does not start it. check for spark. a weak battery also will flood the car.
there is a few ways to de-flood the car. 1. remove the fuel pump relay under the dash bolted to the steering column (if in the original place). has a yellow base and black top. then crank. 2. remove fuel feed line, clamp closed or plug. then crank. ( this will also let you know if you have fuel pressure if removing the plug or clamp from the line and if gas flows, you have pressure. but its better to test on the return side so you know fuel passed all the way though the rails) theres many more ways, but im sure you get the idea. stop the fuel. and crank it. after this to clean the chamber out. take out the trailing plugs and crank. it will shoot out the gunk form the motor. put brand spanking new plugs. if she still dosnt start. you have deeper problems. if it does start, she will be smoking a lot from the auto tranny fluid. this also helps to clean off carbon and kinda repair oil seals in the motor. many people do this after a certain milage anyway to clean up the motor. just let her high idle (1500-2000) for atleast 15 minutes with a hit of the throttle every now and again. a drive with a few full throttle runs to 8k will clean out the smoke also. |
Link to Aaroncake's web page
click for info to get started on this |
just push start it. there shouldnt be any damage as long as u have oil in the engine.
|
FUEL SPARK COMPRESSION do you have them?
If the car is NA take the walboro out! |
Originally Posted by sen2two
(Post 9045692)
does it turn over fine? if it been sitting that long, squirt a little of auto tranny fluid into each rotor through the spark plug hole. this adds to compression for an easier start. then get some starting fluid and spray it into the throttle body as you crank. if this does not start it. check for spark. a weak battery also will flood the car.
there is a few ways to de-flood the car. 1. remove the fuel pump relay under the dash bolted to the steering column (if in the original place). has a yellow base and black top. then crank. 2. remove fuel feed line, clamp closed or plug. then crank. ( this will also let you know if you have fuel pressure if removing the plug or clamp from the line and if gas flows, you have pressure. but its better to test on the return side so you know fuel passed all the way though the rails) theres many more ways, but im sure you get the idea. stop the fuel. and crank it. after this to clean the chamber out. take out the trailing plugs and crank. it will shoot out the gunk form the motor. put brand spanking new plugs. if she still dosnt start. you have deeper problems. if it does start, she will be smoking a lot from the auto tranny fluid. this also helps to clean off carbon and kinda repair oil seals in the motor. many people do this after a certain milage anyway to clean up the motor. just let her high idle (1500-2000) for atleast 15 minutes with a hit of the throttle every now and again. a drive with a few full throttle runs to 8k will clean out the smoke also.
Originally Posted by nillahcaz
(Post 9045813)
Link to Aaroncake's web page
click for info to get started on this thank you
Originally Posted by cozmosland
(Post 9046139)
just push start it. there shouldnt be any damage as long as u have oil in the engine.
Originally Posted by iceblue
(Post 9046165)
FUEL SPARK COMPRESSION do you have them?
If the car is NA take the walboro out! Thank you all for posting i know you gusy are probably annoyed by these questions already! |
The NA wont run or will run at best horridly and will flood very often with that pump without an after market FPR setup. It sounds like the car is flooded and guess why?
|
okay, okay so i'll get one asap but should i do what was stated earlier? with the auto tranny fluid and such.
|
also seeing as how the car is an S5 he can just floor the gas pedal and crank it. That IIRC is the way to deflood the S5's
|
i thought it was the other way around
|
should i try the seafoam method?
|
Originally Posted by NJGreenBudd
(Post 9045630)
So what are you asking?
Yes you need a FPR, are you getting fuel into the housings? |
no ATF is not best way nor is sea foam use MMO. The gas pedal on S5 cars only shuts the fuel off during cranking or pull the EGI-INJ fuse in the bay. If its that flooded you will need to crank it for ab it with the plugs out anyways. There is some custom work involved or new parts required to address the factory FPR and fuel delivery options to work with the after market FPR so it would be easiest for now to just use a OEM pump. Be careful of places like O'reilys they use the same part number to address FC,FD's, and supras fuel pumps.
|
marvels mystery oil is ATF
could be the fuel filter is clogged |
Originally Posted by walken
(Post 9049115)
marvels mystery oil is ATF
could be the fuel filter is clogged |
what part of miami are u in...I can help if needed
|
Originally Posted by walken
(Post 9049115)
marvels mystery oil is ATF
could be the fuel filter is clogged Close but not quite much higher detergent lighter body far easier to burn. |
^^ i don't understand your post iceblue? well should i stop and have it towed to a mechanics shop?(rotary of course) since i don't know any other mechanical issues are left.
|
I read the part where you say it starts if starter fluid is used. So it's a fuel delivery problem.
So since it's a non turbo, jumper the yellow two socket fuel pump check connector. Key to ON. The pump should be heard running continuosly. Good. Now remove the jumper wire from the connector and remove the Return Line on the left side of the engine. It's the one that does not come from the fuel filter (filter is below the brake booster area). Now with the key ON, go jumper that yellow two socket fuel pump check connector momentarily. Fuel should flow out the return hard line. IF not, leave the jumper in a bit longer and see if it flows not. Not flowing??? Leave the jumper in for ten or fifteen seconds. No fuel? Lines are plumbed wrong or clogged or????? |
Originally Posted by sen2two
(Post 9045692)
does it turn over fine? if it been sitting that long, squirt a little of auto tranny fluid into each rotor through the spark plug hole. this adds to compression for an easier start. then get some starting fluid and spray it into the throttle body as you crank. if this does not start it. check for spark. a weak battery also will flood the car.
there is a few ways to de-flood the car. 1. remove the fuel pump relay under the dash bolted to the steering column (if in the original place). has a yellow base and black top. then crank. 2. remove fuel feed line, clamp closed or plug. then crank. ( this will also let you know if you have fuel pressure if removing the plug or clamp from the line and if gas flows, you have pressure. but its better to test on the return side so you know fuel passed all the way though the rails) theres many more ways, but im sure you get the idea. stop the fuel. and crank it. after this to clean the chamber out. take out the trailing plugs and crank. it will shoot out the gunk form the motor. put brand spanking new plugs. if she still dosnt start. you have deeper problems. if it does start, she will be smoking a lot from the auto tranny fluid. this also helps to clean off carbon and kinda repair oil seals in the motor. many people do this after a certain milage anyway to clean up the motor. just let her high idle (1500-2000) for atleast 15 minutes with a hit of the throttle every now and again. a drive with a few full throttle runs to 8k will clean out the smoke also. To unflood an S5, all you need to do is floor the gas pedal. Simple as that. |
dont use any thing besides regular motor oil. you use ATF or MMO when you know the engine is trash and want to get it runing on its last legs of its life.
do what hailers suggested, then if everything works, yank the injectors out and sent them off to witchhunter performance. if that still doesnt work, get a NA fuel pump. ill give you my working s5 NA unit for free. just pay shipping. |
Originally Posted by incubuseva
(Post 9051089)
Whoa whoa whoa there kiddo. Auto tranny fluid? Won't that ruin seals? Use regular oil instead, like he said he did.
To unflood an S5, all you need to do is floor the gas pedal. Simple as that. |
Originally Posted by j9fd3s
(Post 9051250)
how does ATF ruin cast iron? the seals are iron. ATF just makes HUGE clouds of smoke.
|
All times are GMT -5. The time now is 10:25 PM. |
© 2024 MH Sub I, LLC dba Internet Brands